The emergence of floor washing machines has changed the original cleaning methods and also improved the living and working environment. With the development of science and technology, today's floor washing machines have become more and more "foolish" and easier to use! As long as users are given a little training, they can master and use it in a short time. Floor scrubbers are widely used in all walks of life, such as hotels, hotels, clubs, airports, subway stations, shopping malls, cigarette factories, electronics factories, automobile and parts production plants, etc. Even our national stadium has floor scrubbers.

We all know that cigarette factories have a large area and it will be very difficult to clean manually. Although the floor is not dirty, the large area is time-consuming and labor-intensive, and it requires a lot of labor, which is very uneconomical. This time it’s time to talk about using a floor scrubber. Not only is it clean, but it also saves labor. In general cigarette factories, it is suitable to use a driving floor washer. Compared with a hand-push floor washer, it is not only more efficient, but also very easy. You can easily control it while sitting on the floor washer. Next, let’s talk about the operation:

To perform any cleaning operation, we need water, which is injected into the machine through the clean water injection port, and the clean water will automatically flow into the clean water tank for later use.

To clean the floor, it is not enough to just put clean water and detergent into the clean water tank. We also need to discharge it to the ground. At this time, you need to turn on the clean water volume control switch, so that the clean water with detergent will be discharged to the ground along the clean water discharge pipe. If the disk brush or roller brush is equipped with a continuous operation, the stains on the ground will be eliminated.

If you only do this part, the floor washing operation is done, but what about the sewage on the ground? Don't worry, all floor washing machines are equipped with a squeegee head at the back. Although their shapes are different, the basic principle is still the same. The rubber strip on the squeegee head can effectively block the water flow, and the suction hole on it is connected to the suction motor of the machine. In this way, when the suction motor is started, the sewage on the ground will enter the sewage tank along the suction pipe.

Speaking of the sewage tank, there is a lot of knowledge here. As mentioned above, the machines are equipped with water suction motors and are located near the sewage tank. When sewage containing detergent enters the sewage tank, it will generate foam. As these foams continue to increase, it will inevitably reach the water suction motor, causing the water suction motor to burn out. To avoid this, please be sure to add defoaming agent to the sewage tank before absorbing water. This will avoid damaging the motor.

It seems that everything in the world has its carrying capacity, and the same is true for the sewage tank of the tobacco factory floor washing machine. When the sewage tank becomes full, please stop operating and place the machine in an area with a drainage device to drain the sewage tank before proceeding with the next operation.

The above describes the working principle of the floor washing machine. During the working process, you also need to pay attention to:

1. During the cleaning operation, it is necessary to pay attention to the slope of the cleaning floor not being greater than the slope that the detergent can withstand, otherwise it will lead to poor work results and the risk of tipping.

2. The cleaning agents and defoaming agents used must comply with safety regulations and should not be excessive.

3. When the working effect is not good, it needs to be properly repaired.

4. Keep away from children during work to avoid danger to them

5. The accessories used by the machine must be original. The use of non-original accessories may affect the working effect.

After understanding the working principle and precautions of the floor washing machine, I believe that we will use the floor washing machine well and clean the floor. Especially in summer, it is a bonus. The hot weather will no longer make the cleaning staff sweaty because of mopping the floor. Therefore, if the tobacco factory chooses a floor scrubber for cleaning, it is a treasure to choose the right one!